Bamboo Fiber Properties And Identification Methods
One Bamboo pulp fiber And others Fiber properties compare
1.1 comparison of suction, moisture release and cooling properties of bamboo pulp, cotton and polyester
According to the test method of water drying loss rate of fabric, the moisture absorption and cooling properties of bamboo pulp fiber, cotton and polyester were measured by the water droplet diffusion time and diffusion area test method. Table 1.
Table 1 bamboo pulp fiber, cotton and polyester moisture, moisture and cool
Characteristics and comments
Valence method
Suction and moisture release
(delta MR) /%
Contact cold sensation
(Qmax) /W. Cm
-2
100% bamboo pulp fiber
Eight point nine
0.15~0.16
Bamboo pulp / polyester 50/50
Four point two
0.12~0.14
100% cotton
4.0%~4.5%
>0.11
Polyester / cotton 50/50
-
0.044~0.045
Polyester / wool 50/50
-
0.09~0.11
Note: the two indexes of surface suction, moisture release value and contact cold sensation indicate moisture absorption and moisture release.
It can be seen from table 1 that the suction and moisture release of bamboo fiber textile is 2.12 times that of cotton. The moisture absorption of bamboo pulp / polyester 50/50 fabric is close to cotton, indicating that the fabric has high moisture absorption and quick dry property, and its touch is cooler than cotton, wool and polyester fabric.
1.2 comparison of hygroscopicity of bamboo fiber and viscose
The moisture absorption property of bamboo pulp fiber is obviously higher than that of other fibers, which is known as breathing fiber in industry. The moisture regain of bamboo pulp fiber in standard condition is 13%, which is similar to viscose fiber. However, when bamboo pulp fiber is at 20 and 95% relative humidity, moisture regain can reach 45%, moisture absorption speed is very fast, moisture regain is increased from 8.75% to 45%, only 6h.
The moisture regain of viscose fiber at 20 and 95% relative humidity is 30%, and moisture regain is increased from 9.12 to 30%, which needs more than 8h.
1.3 bacteriostasis of bamboo pulp fiber, cotton and viscose
Bamboo fiber has
Table 2 bacteriostatic test of bamboo fiber, cotton fiber and viscose fiber
Fiber types Bacteriostatic rate /%
Staphylococcus aureus
Escherichia coli
Candida albicans
Bamboo pulp fiber
99.44%
Ninety-nine point one nine
94.09%
cotton
-
-
40.10%
Viscose fiber
59.65%
Fifty-eight point three six
75.26%
It can be seen from table 2 that the antibacterial property of cotton fiber is poor, the antibacterial property of viscose fiber is not obvious, and bamboo pulp fiber has good bacteriostatic effect, and its bacteriostatic effect has certain broad-spectrum effect.
1.4 deodorizing effect comparison of bamboo pulp and cotton
Bamboo pulp fiber has a natural odor resistance, mainly fiber contains chlorophyll and chlorophyllin, copper and other odorant substances, these odorant substances through the adsorption odor and oxidation decomposition way to remove odor, in addition, bamboo fiber fast sweat, so that the microorganism's survival environment is poor, also can achieve the effect of deodorization.
The results of comparative experiments are shown in Table 3.
Table 3 Comparison of deodorizing effect between bamboo pulp and cotton
Deodorization rate
swatch
Deodorization rate of ammonia /%
Deodorizing rate /% for acid odor
Original sample
Specimen 1
Specimen 2
Original sample
Specimen 1
Specimen 2
Bamboo cloth
Seventy-five
Seventy-two
Seventy
Ninety-seven
Ninety-two
Ninety-three
Pure cotton fabric
Thirty
Twenty-eight
Twenty-six
Eighty-six
Eighty-two
Seventy-eight
Note: sample 1 is washed for 5 times, and the sample 2 is deodorizing 30 times after washing.
1.5 comparison of heat resistance of bamboo pulp, cotton and viscose
The heat resistance of viscose fiber is higher than that of cotton, while the heat resistance of bamboo fiber is better than that of viscose fiber. The strength change of cellulose fiber when heating is as shown in Table 4.
Table 4 strength changes of cellulose fibers during heating up
fibre
type
Dry fracture strength / (cN/dtex)
20 C
50 C
75 C
100 C
Viscose fiber
Two point two seven
Two point three nine
Two point five five
Two point one four
Cotton fiber
Three point eight
Three point zero five
Two point eight three
Two point six three
Bamboo pulp fiber
Two point two three
Two point three zero
Two point five one
Two point four nine
從表中數據可以看出，當溫度由20℃升至75℃時，棉纖維的干斷裂強度下降了26%，粘膠纖維的干斷裂強度增加了12%，竹漿纖維的干斷裂強度增加了13%，說明在75℃時以下時粘膠纖維和竹漿纖維強度的變化相同；當溫度由75℃升至100℃時，棉纖維的干斷裂強度下降了7%，粘膠纖維的干斷裂強度下降了16%，而竹漿纖維的干斷裂強度卻只下降了1%，其原因在于：1）纖維素中水份消失而引起強度的改變；2）由于大分子間各鏈節的熱運動加劇而引起的強度降低；3）天竹纖維的多孔隙網狀結構對熱量傳導有緩沖作用；4）竹漿纖維、粘膠溶解性和白度比較；4）溶解度：竹漿纖維的溶解度比粘膠纖維要大，竹漿纖維在55.5％的硫酸溶液中的溶解度為32.16％，粘膠纖維為19.07%；5）白度：竹漿纖維白度一般在67%左右，粘膠纖維白度在72%以上。
2 Comparison of cross sections of several fibers
The identification of bamboo fiber has been perplexing the development of bamboo pulp fibers. The main difficulty is the difference from ordinary viscose fibers. The major scientific research institutes in China have also carried out research, such as dyeing method, cell observation method, gas phase spectrum method and liquid chromatography method. No breakthrough has been made. Therefore, the quantitative identification of bamboo pulp fiber is listed as a worldwide problem by industry experts.
We are also committed to the study of this method. After several years' efforts, we have analyzed and summarized the identification criteria of textile materials, and explored the structural differences between bamboo fiber and viscose fiber.
2.1 cross sectional images of viscose fibers from different production enterprises
JJG chemical fiber viscose fiber cross section of Jilin chemical fiber viscose fiber
Hailong chemical fiber viscose fiber cross section Sanyou chemical fiber viscose fiber cross section
Cross-sectional section of high density chemical fiber viscose fiber
From the cross section of each fiber, the cross section shape is similar, the core layer structure is homogeneous, the cross section is smooth, not the pore structure.
2.2 cross sectional picture of bamboo fiber of different specifications of yarn and fabric
0.89dtex cross section 1.11dtex bamboo fiber cross section of bamboo pulp fiber
1.33dtex cross section 1.56dtex bamboo fiber cross section of bamboo pulp fiber
3.33dtex cross section of bamboo fiber cross section bamboo fiber yarn
Cross section of bamboo fiber fabric cross section bamboo fiber T-shirt
Cross section of bamboo fiber underwear cross section bamboo fiber socks
From all fiber cross sections, bamboo fiber has unique skin core mechanism. It seems to have a cavity in the middle, and is not affected by spinning force and dyeing conditions. Compared with viscose fiber, it has unique cross-sectional structure. It can be used as a way to identify viscose fiber and bamboo fiber.
- Related reading
- Fashion makeup | Do Not Come Up With Oil To Moisturize &Nbsp; DIY Moisturizing Facial Mask Run Zeji
- Design Frontiers | 一個下崗女工開花店的成功創業!
- Topic for people's livelihood | 五大行業一線員工薪酬調查：每月難超2000元
- Industry leader | Cao Dewang: I Hope More Entrepreneurs Will Invest In Public Welfare Undertakings.
- Investment leisure | Sale Of Shoes After Sale Is Bad.
- Fashion makeup | Bubble Paper Film Whitening Toner &Nbsp; Persistence Will Be White.
- Listed company | Xugong Remarried China Weapons Group
- Successful case | Grand $100 Million Set Up A Special Fund &Nbsp; Plot Digital Copyright.
- Fashion makeup | Seize The Right Time! Physique Removing Pock Marks
- Topic for people's livelihood | The Three Network Fusion Scheme Formally Issued &Nbsp; The List Of Pilot Cities Was Unveiled This Month
- Online Shopping Nike Suspect Counterfeit: Size Is Not &Nbsp; Rough Workmanship
- 柴油荒背后映射的是“制度荒”
- Zhang Hanyun'S Wounds Were Exposed And Changed To Sweet Style.
- 東莞國際鞋展·鞋機展下屆展會將于明年四月舉行
- South Africa Adopts Trade Protection Measures &Nbsp; Chinese Clothing Enterprises Are Affected.
- “電視棒”涉黃 可能構成傳播淫穢物品罪
- The "Korean Wave" Infiltrated &Nbsp Into China; The First Stop Was Aimed At Jiangcheng, China.
- Dongguan International Shoe Show Shoe Machine Exhibition Was Cold At Department Stores
- Kimono "Wear Uncomfortable" &Nbsp; This Year'S APEC Summit Is Not Uniform.
- Shuangfeng Actively Takes Over The Shoe Industry &Nbsp And Builds Harmonious Labor Relations.