Textile Industry Ushered In The "Golden Nine" New Situation, Printing And Dyeing Market Has Not Improved

"We do elastic fabrics. Recently, our customers have placed a lot of orders. Now we have a 350000 meter piece in hand, and another 250000 meter one. The order can basically be achieved in December."

"We are mainly engaged in warp knitted fabrics. The market in September is slightly better than that in August. At this stage, orders can be executed to the end of September, mainly suede."

"Our main products are memory T400, high elastic four-way bullet, Rensi rayon and so on. Now the order quantity is stable and can last till the end of the year."

……

This wave of market improvement is not only expected, but also unexpected. On the one hand, because it is in the traditional peak season of textile, autumn and winter fabrics will inevitably appear in this period. On the other hand, many brand clothing enterprises have clearly reduced or cancelled the autumn and winter orders because of the epidemic.

However, textile orders are always good news, but this wave of improvement is limited and not thorough. Because most of them only stay in the trade side, and the printing and dyeing end has not changed. Even compared with August, it still has a decline. The start-up remains at a low level, and the delivery time is very short.

The operating rate is 60%, and the delivery time is less than 7 days

Contrary to the situation on the trade side, orders in the whole printing and dyeing market not only did not improve in September, but also declined compared with last month. Even those dyeing factories that were able to process elastic fabrics in the early stage and burst into warehouses and pressed cards were gradually losing heat and returning to calm.

According to the introduction of the situation, when the gray dyeing enterprises are in charge of more than 400000 meters / day, they can only take charge of about 700000 meters / day. It is reasonable to have these quantities in August this year, even in previous years. Therefore, in general, the factory is still busy. The start-up can be maintained at 70-80%. However, recently, orders have been reduced seriously. The daily warehouse entry is only maintained at 300000-400000 meters, and the start-up in the factory can only be maintained at about 60%.

With the decrease of orders, the delivery time of dyeing plant is relatively short, and the long delivery time will not exceed 15 days, or even 3-5 days. The overall state of dyeing factories is not good, which also leads to the weakness of dyeing fees. On the one hand, in the face of the recent boom in dye prices, the vast majority of dyeing plants are silent response. On the other hand, many dyeing factories take the initiative to contact their customers and clearly indicate that the dyeing fee can be negotiated if there is an order.

The market single disperses, the order quantity is difficult to support the overall situation

The fabric market in the past years, especially in September and October, is bound to be a big burst of dyeing factories. This situation is mainly due to the fact that the market order and the order fabric appear in the dyeing plant at the same time, especially the huge quantity of the market order easily leads to the hot situation of the dyeing factory.

But this year, both the market order and the number of orders have declined a lot compared with previous years, not only in the time point when the two kinds of orders appear, there is also a deviation. The large number of market orders that should have appeared in September were advanced to August, which is why the orders of dyeing factories in August were generally good. In September, however, the number of orders in the market has been reduced since the last few months.

Although the orders of the following traders come down, the same shrinking number is more difficult to support the capacity of dyeing plants. At the same time, because the number of traders engaged in the market list is relatively small, but many are engaged in ordinary orders. As a result, the market appeared a false impression that the orders of the trading side in August were not much, but now there are obvious increases in orders everywhere. It seems that the market is indeed improving. But in fact, the dyeing plant has changed from single market to order, but the quantity is far less than the previous period.

Generally speaking, the improvement degree of the textile market is still limited. The reduction and absence of the market list make the dyeing factory lose a VIP. Perhaps September this year is the weakest peak season for all dyeing factories, but what is more pessimistic is that even those traders who receive orders are also not optimistic about the future market. The overseas epidemic situation continues to worsen, and there is the possibility of a second outbreak in some improved areas, which has drawn a question mark for the sustainability of textile orders.