Knowledge Of Leather Clothing Cleaning Knowledge

There are essential differences between leather materials and all kinds of textile products.

Because of the characteristics of leather, it determines that it is restricted by certain conditions when cleaning.

After repeated wet cleaning, leather clothing may cause the loss of oil tanning agent in leather, and the problem that leather clothing is deformed and hardened due to improper handling of technology in drying and finishing.

These should arouse enough attention.

There are three kinds of dirt that are oil soluble, water-soluble and special.

There are two methods for cleaning and removing these dirt, mechanical cleaning and manual cleaning.

Manual cleaning methods are introduced here.

No matter what form of manual operation.

The method and operation procedure are roughly the same, but the difference between the dirt and the dirt is different. The method of removing the stain and selecting the cleaning agent are slightly different.

First,

Operation procedure

1, prepare worktables, appliances and supplies.

For example, various cleaning agents, cleaning agents, cotton towels, brush, sponge blocks or plastic foam blocks.

2, put the hand-made leather clothing civilian on the worktable.

3, find dirt attached to clothing, and select the appropriate dirt.

Remove cleaning in turn.

4, check dry leather clothing, leather surface, remove the quality of the stain, treat differently.

5, the leather clothing with the requirements of cleaning quality is pferred to the next order.

Smooth leather clothing requires coloring, finishing and maintenance procedures.

Suede leather clothing is pferred to the whole wool process.

Two. Problems in manual cleaning operation.

1, leather clothing cleaning, its key parts: neckline, cuffs, bag mouth, hem, inner flask should pay attention to wash, scrub cotton cloth or towel, brush, sponge block wipe.

Do not use too much cleansing dose every time. Prevent wet soaking of leather garments.

2, leather garment lining cleaning, to prevent excessive force, tear the lining, water volume should not be large.

While cleaning, wipe with clean wool cap repeatedly, avoid water and dirt infiltration into leather.

After cleaning, use the wool cap to dry repeatedly to avoid the appearance of water marks in the lining.

3, when leather clothing cleaning operation, pay attention to moderate force, prevent improper skin abrasion caused by improper strength, and cause artificial damage.

4, after leather clothing is washed, the surface of the leather is dropped and the surface is badly cracked.

Before operation, protective equipment such as rubber gloves, aprons, respirators and ventilation facilities should be prepared.

5, when leather clothing is washed by hand, it is necessary to "wash skin" for special dirt, make small tests at the beginning of the day when clothes are not obvious, and then remove them in large areas, so as to avoid the quality problems that can not be controlled.

The cleaning and cleaning of leather clothing, due to the nature of the nature of the cortex, there is no fixed method of cleaning and cleaning mode.

Only because of the different clothes, "look at the laundry", rely on continuous research and practice, accumulate experience, sum up the rules, and strive to do a good job of washing service.